Spunagain's MG ZT260 Pages

Spunagain's ZT260 pages are under construction.

This page is made up of my own experiences and cullings from the Xpower forums

Servicing

Here is a summary of the service intervals for the 260. 

When you go to the garage make sure they understand which service you want and get a quote for what they think you want.An 'A' service should cost about  £90, a 'B' service £160 is and a 'C' service £300.

 The information below is summarized from the Rover / MG ZT - ZTT Maintenance check sheet (260PS V8 models) RCL 0585(2)EN 03/04
Service type A A B A A C A A B A A C
Miles x 1000 5 10 15 20 25 30 35 40 45 50 55 60
Years

1

2

3

4
Type Oil Oil Inspection Oil Oil Inspection Oil Oil Inspection Oil Oil Inspection

Oil Service Intervals are based on 5,000 miles irrespective of time. An Inspection must be carried out at least once every year as identified in the table above.

No. A B C

        Preliminary Work
1 X X X Before commencing work, check for any outstanding service actions




VEHICLE INTERIOR AND EXTERIOR
2 X X X Fit vehicle protection kit
3

X Replace alarm handset batteries
4
X X Check handbrake operation and adjust if necessary.
5 X X X

Check lamps, horns and system warning indicators
6
X X Check screen for damage and operation of wipers and washers - Adjust washers if required
7
X X Check seatbelt operation, seatbelts and airbag module covers for damage.
8
X X Check air conditioning system operation - If applicable
9

2/30 Replace air intake pollen filter - Every 30,000 miles or 2 years whichever is the sooner
10
X X Lubricate locks, strikers, latches door hinges and door checks


ENGINE BAY
11 X X X Check and top up brake, clutch, power steering and screen washer fluid levels
12
X X Pressure test cooling system and coolant cap, check hoses and connections for signs of leakage and condition - Use tool No 26R001
13
X
Check and record anti freeze content Concentration % or degrees C - ( Concentration must be corrected if below 50% ) - Use tool No 26R003
14
X X Inspect air conditioning system hoses
15
X X Check auxillary drive belts, tension and condition
16

6/90 Replace spark plugs - Every 90,000 miles or every 6 years, whichever is the sooner
17

6/90 Replace PCV valve - Every 90,000 miles or every 6 years, whichever is the sooner
18

2/30 Check condition of engine mountings, paying paticular attention to hydraulic mountings - Every 30,000 miles or 2 years whichever is the sooner
19

4/60 Check torque of accessible engine mounting fixings - Every 60,000 miles or every 4 years, whichever is the sooner
20
X X Connect T4 carry out fault code read
21 X X X Reset Service Interval Indicator in accordance with manufacturers guidelines

With Vehicle on Lift
22

 4/60 Replace antifreeze using vacuum fill process - Every 60,000 miles or 4 years, whichever is the sooner. - Use tool No 26R002
23

 4/60 Check and record anti freeze content Concentration % or degrees C - ( Concentration must be corrected if below 50% ) - Use tool No 26R003
24

8/120 Replace manual gearbox oil - Every 120,000 miles or 8 years, whichever is the sooner
25

 7/105 Replace automatic gearbox oil - Every 105,000 miles or 7 years, whichever is the sooner.
26 X X X Replace engine oil and filter
27

10/150 Replace rear differential oil - Every 150,000 miles or every 10 years, whichever is the sooner
28

 2/30 Replace air cleaner element - Every 30,000 miles or every 2 years, whichever is the sooner
29
X X Check wheel bearings, drive shafts and gaiters
30
X X Mark relative stud and wheel position and remove front and rear road wheels, check wheels for damage.
31 X X X Check tyres for damage, uneven wear and tread depth (mm)
32
X X Visually check front and rear brake pads, discs, calipers, hoses and pipes for wear or damage
33
X X Check parking brake linings - Only if rear brake pads have been replaced
34
X X Inspect for condition and evidence of leakage from fuel, clutch, transmission and engine systems.
35
X X Inspect exhaust system and heat shields
36
X X Inspect suspension and steering systems for signs of leaking or wear.
37

 2/30 Replace brake fluid - Every 30,000 miles or 2 years, whichever is the sooner. - CHARGED SEPARATELY
38
X X Apply anti seize compound to wheel hub and refit road wheels to original hub and stud position

Vehicle exterior stage 2
39
X X Check battery connections and battery condition indicator colour and charge condition.
40
X X Check battery vent hose for correct routing and obstructions
41 X X X Check tyre pressures and adjust if necessary (bar)
42 X X X Check I.T.R (Instant Tyre Repair) for previous usage and expiry date of sealant
43 15 Yrs
   Replace airbag module(s) Seat belt pre tensioners and rotary coupler - CHARGED SEPARATELY

After each service
44
X X Annual corrosion/cosmetic inspection - Using annual corrosion inspection sheet
45
X X Replace antifreeze using vacuum fill process - Every 60,000 miles or 4 years, whichever is the sooner. - Use tool No 26R002

The maintenance items listed are those recommended for vehicles operating under normal driving, road and climatic conditions. More frequent attention may be necessary if the vehicle is subject to stop/start operation, extremes of temperature, dusty conditions or frequent towing of trailers.
ZT260 page
home
This web page is designed and maintained entirely by Spunagain.  Please let me know if you have new information or anything here is demonstrably incorrect!
Thanks.
Spunagain <questions@spunagain.co.uk>